[an error occurred while processing this directive] [an error occurred while processing this directive]

2004 Volkswagen Beetle Recalls

What To Do If Your Beetle Has Been Recalled

The following recalls have been announced by Volkswagen, so if you own a 2004 Beetle take action immediately to get your automobile fixed. Interested in how this information is collected? Read more about recalls and the NHTSA.

  1. Call Volkswagen to get more information. Verify that the cost of repairs will be covered free of charge.
  2. Setup an appointment with a local authorized mechanic to schedule your maintenance.
  3. Keep up to date with recalls for your vehicle by following this page.

Recent 2004 Beetle Recalls

  • ENGINE AND ENGINE COOLING:ENGINE Recall for 2004 Volkswagen Beetle

    • Recall Announced MARCH 07 2014
    • NHTSA Reference #14E007000
    • Number Affected 50

    Summary: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

    Consequence: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

    Fix: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #14E007000 »

  • EXTERIOR LIGHTING Recall for 2004 Volkswagen Beetle

    • Recall Announced APRIL 07 2009
    • NHTSA Reference #09E012000
    • Number Affected 16,270

    Summary: Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." These lamps do not contain the required amber side reflectors.

    Consequence: Decreased lighting visibility may result in a vehicle crash.

    Fix: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009. Owners may contact sabersport at 1-909-598-7589.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #09E012000 »

  • AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE Recall for 2004 Volkswagen Beetle

    • Recall Announced APRIL 17 2008
    • NHTSA Reference #08V178000
    • Number Affected 76,900

    Summary: Volkswagen is recalling 76,900 MY 2004-2005 new Beetle and MY 2003-2005 new Beetle convertibles equipped with an advanced (dual-stage) air bag system. This system may have air bag frontal crash sensors that contain a solder joint on the circuit board that may crack under certain high temperature conditions. If this occurs, the air bag indicator light will illuminate and the fallback algorithm will ensure that the front air bags always deploy in a frontal crash in which the vehicle's deceleration is high enough to activate the frontal air bags.

    Consequence: In low-severity frontal impacts, the front air bags may deploy more forcefully than designed, increasing the possibility of injury to out-of-position front seat occupants.

    Fix: Dealers will inspect each vehicle to determine that the specific defect crash sensor is present on one or both sides of the vehicle. All of the defect crash sensors will be replaced free of charge. The recall is expected to begin on or before July 31, 2008. Owners may contact Volkswagen at 1-800-822-8987.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #08V178000 »

  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER Recall for 2004 Volkswagen Beetle

    • Recall Announced MARCH 29 2007
    • NHTSA Reference #07E023000
    • Number Affected 13,128

    Summary: Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.

    Consequence: Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

    Fix: Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during April 2007. Owners can contact cardone at 1-800-777-4780.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #07E023000 »

  • EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH Recall for 2004 Volkswagen Beetle

    • Recall Announced FEBRUARY 20 2007
    • NHTSA Reference #07V063000
    • Number Affected 1,002,000

    Summary: On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

    Consequence: The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

    Fix: Dealers will install the newly designed brake light switch free of charge. The recall began on April 27, 2007, and will be conducted in several staggered mailings through September 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06V-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact VW at 1-800-822-8987.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #07V063000 »

  • FUEL SYSTEM, DIESEL Recall for 2004 Volkswagen Beetle

    • Recall Announced DECEMBER 15 2004
    • NHTSA Reference #04V586000
    • Number Affected 19,284

    Summary: On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

    Consequence: Fuel leakage in the presence of an ignition source may lead to a fire.

    Fix: Dealers will replace the diesel pump. The recall began on February 8, 2005. Owners should contact Volkswagen at 1-800-822-8987.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #04V586000 »

  • EQUIPMENT:OTHER:LABELS Recall for 2004 Volkswagen Beetle

    • Recall Announced DECEMBER 04 2003
    • NHTSA Reference #03V508000
    • Number Affected 15,115

    Summary: On certain passenger vehicles, the tire information label is incorrect identifying the vehicle as a five-passenger vehicle, instead of a four-passenger vehicle.

    Consequence: Exceeding the correct seating capacity in a vehicle puts occupants at risk for injury in a crash, and can result in vehicle overloading, which can affect vehicle handling and put you at risk for a crash.

    Fix: Owners will be sent a new label and installation instructions. Owner notification began on February 9, 2004. Owners should contact vwoa at 1-800-822-8987.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #03V508000 »

  • AIR BAGS Recall for 2004 Volkswagen Beetle

    • Recall Announced SEPTEMBER 29 2003
    • NHTSA Reference #03V356000
    • Number Affected 333

    Summary: On certain passenger vehicles, the passenger detection function of the passive occupant detection system (pods) may become disabled.

    Consequence: Should the pods control unit malfunction, the air bag system in the vehicle will not work as designed and may not be able to properly protect occupants in a crash.

    Fix: Dealers will reprogram the pods. Owner notification originally began October 3, 2003. VW has determined that additional vehicles need to be repaired. The recall for the additional vehicles is expected to begin on December 17, 2004. Owners should contact vwoa at 1-800-822-8987.

    For detailed information & supporting documents, see the official NHTSA page concerning recall #03V356000 »

[an error occurred while processing this directive] [an error occurred while processing this directive] [an error occurred while processing this directive]
[an error occurred while processing this directive]